Cummins B3.9, B4.5 & B5.9 Engines – Operation and Maintenance Manual

Introduction, To the Owner and Operator, About the Manual, How to Use the Manual, Symbols, Illustrations, General Safety Instructions, General Repair Instructions, General Cleaning Instructions, Acronyms and Abbreviations, Engine and System Identification, Engine Identification, Engine Diagrams, Operating Instructions, Operating Instructions, Normal Starting Procedure, Cold Weather Starting, Starting Procedure After Extended Shutdown or Oil Change, Operating the Engine, Operating Range, Engine Shutdown, Electromagnetic Interference (EMI), Maintenance Guidelines, Maintenance Guidelines, Overview, Maintenance Schedule, Maintenance Record Form, Maintenance Procedures at Daily Interval, Daily Maintenance Procedures, Air Intake Piping, Air Tanks and Reservoirs, Fan, Cooling, Crankcase Breather Tube, Coolant Level, Drive Belts, Fuel-water Separator, Lubricating Oil Level, Maintenance Procedures at 250 Hours or 3 Months, Maintenance Procedures, Air Cleaner Restriction, Air Compressor, Charge-air Cooler, Charge-air Piping, Fuel Pump, Radiator Hoses, Closed Crankcase Ventilation Hoses, Maintenance Procedures at 500 Hours or 6 Months, Maintenance Procedures – Overview, Engine Coolant Antifreeze, Fuel Filter (Canister Type), Fuel Filter (spin-on Type), Lubricating Oil and Filters, Maintenance Procedures at 1000 Hours or 1 Year, Maintenance Procedures – Overview, Cooling Fan Belt Tensioner, Fan Hub, Belt Driven, Overhead Set, Maintenance Procedures at 2000 Hours or 2 Years, Maintenance Procedure, Air Compressor Discharge Lines, Cooling System, Vibration Damper, Rubber, Vibration Damper, Viscous, Adjustment, Repair, And Replacement, Air in Fuel, Alternator, Air Cooler, Cooling Fan Belt Tensioner, Drive Belt, Cooling Fan, Fan Spacer and Pulley, Starting Motor, System Diagrams, Overview, Flow Diagram, Fuel System, Flow Diagram, Lubricating Oil System, Flow Diagram, Cooling System, Flow Diagram, Air Intake System, Flow Diagram, Exhaust System, Flow Diagram, Compressed Air System, Service Literature, Additional Service Literature, Literature Ordering Location, Component Manufacturers, Component Manufacturers Addresses, Service Assistance, Routine Service and Parts, Emergency and Technical Service, Problem Solving, Division and Regional Offices, Troubleshooting Symptoms, Troubleshooting Procedures and Techniques, Troubleshooting Symptom Charts, Air Compressor Air Pressure Rises Slowly, Air Compressor Cycles Frequently, Air Compressor Noise Is Excessive, Compressor Pumping Excess Lubricating Oil Into the Air System, Compressor Will not Maintain Adequate Air Pressure, Compressor Will not Stop Pumping, Alternator not Charging or Insufficient Charging, Alternator Overcharging, Coolant Contamination, Coolant Loss – External, Coolant Temperature Above Normal, Gradual Overheat, Sudden Overheat, Coolant Temperature Is Below Normal, Engine Acceleration or Response Poor, Engine Difficult to Start or Will not Start, Engine Difficult to Start or Will not Start, Engine Noise Excessive, Engine Noise Excessive, Engine Power Output Low, Engine Runs Rough at Idle, Engine Runs Rough or Misfires, Engine Shuts Off Unexpectedly or Dies During Deceleration, Engine Speed Surges at Low or High Idle, Engine Speed Surges Under Load or in Operating Range, Engine Starts But Will not Keep Running, Engine Vibration Excessive, Engine Will not Crank or Cranks Slowly, Engine Will not Shut Off, Fuel in Coolant, Fuel in the Lubricating Oil, Fuel or Lubricating Oil Leaking From Exhaust Manifold, Lubricating Oil Consumption Excessive, Lubricating Oil Contaminated, Lubricating Oil Loss, Lubricating Oil Pressure High, Turbocharger Leaks Engine Oil or Fuel, Maintenance Specifications, General Engine, Fuel System, Lubricating Oil System, Cooling System, Air Intake System, Exhaust System, Lubricating Oil Recommendations and Specifications, Engine Component Torque Values, Warranty, Highway Engines United States and Canada, California Emission Control System Warranty…

• Pages: 287
• Size: 4.23 MB
• Format: PDF (Adobe Reader)
• Content: Manual for Cummins B3.9/B4.5/B5.9 Series Engines – Operation, Maintenance, Introduction, Identification, Operating Instructions, Maintenance Guidelines, Procedures at Daily Interval, Adjustment, Repair, Replacement, System Diagrams, Service, Component Manufacturers, Service Assistance, Troubleshooting Symptoms, Maintenance Specifications and Warranty Manual

MANUAL – OPERATION – MAINTENANCE – CUMMINS – ENGINES – OPERATING – PROCEDURES – REPAIRING – SYSTEMS – COMPONENTS – SERVICE – TROUBLESHOOTING